Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 SAMMY'S PIZZA OF KANKAKEE 		License/Permit #
 KK175
Street Address
690 N FIFTH AVE
City/State
 KANKAKEE, IL 		ZIP Code
 60901
No. of Risk Factor/Intervention Violations 6
No. of Repeat Risk Factor/Intervention Violations 3
Date 06/09/2021
Time In 04:05 PM
Time Out 05:30 PM
Permit Holder
SCOTT MANAU 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected X X
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used X  

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36 X Thermometers provided & accurate X  

FOOD IDENTIFICATION

 
37 X Food properly labeled; original container X  

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39 X Contamination prevented during food preparation, storage & display X  
40   Personal cleanliness    
41 X Wiping cloths: properly used & stored X  
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49   Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55 X Physical facilities installed, maintained & clean   X
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58 X Allergen training as required    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: SAMMY'S PIZZA OF KANKAKEE Establishment #: KK175
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: QUAT: 400 Heat: <160F °F
CFPM Verification (name, ID#, expiration date):


01/01/1900

01/01/1900

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
chicken/true refrigerator 40.00°F /arctic air commercial freezer -1.00°F cut tomatoes/reach-in cooler/prep-station 55.00°F
pepperoni/pizza prep-station/prep-cooler 55.00°F chicken/cooler below grill 39.00°F tomato sauce/portable warmer - kitchen 145.00°F

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
3 PF Violation (2-103.11(N)): Food employees and conditional employees are informed in a verifiable manner of their responsibility to report in accordance with Law, to the Person in charge, information about their health and activities as they relate to diseases that are transmissible through food, as specified under 2-201.11(A); In violation of 2-103.11(O): written procedures and plans, where specified by the Code and as developed by the Food establishment, are maintained and implemented as required. Corrective Action: The establishment shall have documentation that provides evidence that employees have been informed of their responsibility to report information about their health and activities as they relate to diseases that are transmissible through food to the person in charge. - (Correct By: Jun 21, 2021)
5 PF 2-501.11: A FOOD ESTABLISHMENT shall have procedures for EMPLOYEES to follow when responding to vomiting or diarrheal events that involve the discharge of vomitus or fecal matter onto surfaces in the FOOD ESTABLISHMENT. The procedures shall address the specific actions EMPLOYEES must take to minimize the spread of contamination and the exposure of EMPLOYEES, consumers, FOOD, and surfaces to vomitus or fecal matter.
The establishment has no written procedure for employees to follow when cleaning up fecal matter or vomitus; also, the kit is incomplete--the facility does not have any absorbent material to clean-up after a vomiting or diarrheal event. Corrective Action: create a written procedure for cleaning up fecal matter and vomitus and put together a complete diarrheal and vomiting clean-up kit. - (Correct By: Jun 21, 2021)
15 P 3-302.11 (A) (1): FOOD shall be protected from cross contamination by:   (1) Except as specified in (1)(c) below, separating raw animal FOODS during storage, preparation, holding, and display from: (a) Raw READY-TO-EAT FOOD including other raw animal FOOD such as FISH for sushi or MOLLUSCAN SHELLFISH, or other raw READY-TO-EAT FOOD such as fruits and vegetables, and (b) Cooked READY-TO-EAT FOOD; (c) Frozen, commercially processed and packaged raw animal FOOD may be stored or displayed with or above frozen, commercially processed and packaged, ready-to eat food.
Raw chicken is being stored next to prepped food within the true refrigerator located within the kitchen. - COS,Repeat (Correct By: Jun 9, 2021)
16 P 4-501.114 (C): (C) A chemical SANITIZER used in a SANITIZING solution for a manual or mechanical operation at contact times specified under ¶4-703.11(C) shall meet the criteria specified under §7-204.11 Sanitizers, Criteria, shall be used in accordance with the EPA- registered label use instructions, and shall be used as follows: (C) A quaternary ammonium compound solution shall: (1) Have a minimum temperature of 24°C (75°F), (2) Have a concentration as specified under § 7-204.11 and as indicated by the manufacturer's use directions included in the labeling, and (3) Be used only in water with 500 MG/L hardness or less or in water having a hardness no greater than specified by the EPA-registered label use instructions.
The dishwasher does not dispense sanitizer at the proper concentration (<200 PPM of a QUAT solution). All equipment shall be sanitized within the sanitizer compartment of the 3-compartment sink. - (Correct By: Jun 10, 2021)
22 P 3-501.16(A)(2): (A) Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under §3-501.19, and except as specified under ¶ (B) and in ¶ (C ) of this section, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be maintained: (2) At 5ºC (41ºF) or less.
The two reach-in coolers located in the kitchen were observed to be holding at 50F to 55F. Product within those coolers were stocked today. All products shall be discard after four hours. Use labeling to track time to ensure product is discard in a timely manner. - (Correct By: Jun 10, 2021)
28 P 7-201.11: POISONOUS OR TOXIC MATERIALS shall be stored so they can not contaminate FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE­ SERVICE and SINGLE-USE ARTICLES by: (A) Separating the POISONOUS OR TOXIC MATERIALS by spacing or partitioning; and (B) Locating the POISONOUS OR TOXIC MATERIALS in an area that is not above FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE or SINGLE-USE ARTICLES. This paragraph does not apply to EQUIPMENT and UTENSIL cleaners and SANITIZERS that are stored in WAREWASHING areas for availability and convenience if the materials are stored to prevent contamination of FOOD, EQUIPMENT, UTENSILS, LINENS, and SINGLE-SERVICE and SINGLE-USE ARTICLES.
Bleach containers are stored next to to cutlery packets on the lower shelf of the prep table located in the kitchen near the 3-compartment sink. - COS (Correct By: Jun 9, 2021)
36 C 4-204.112 (B-C): (B) Except as specified in¶(C) of this section, cold or hot holding EQUIPMENT used for TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be designed to include and shall be equipped with at least one integral or permanently affixed TEMPERATURE MEASURING DEVICE that is located to allow easy viewing of the device's temperature display. 4-204.112 Temperature Measuring Devices.(C) Paragraph (B) of this section does not apply to EQUIPMENTfor which the placement of a TEMPERATURE MEASURING DEVICE is not a practical means for measuring the ambient air surrounding the FOOD because of the design, type, and use of the EQUIPMENT, such as calrod units, heat lamps, cold plates, bainmaries, steam tables, insulated FOOD transport containers, and salad bars.
Observed no thermometer within the pizza prep station. - COS (Correct By: Jun 9, 2021)
37 C 3-302.12: Except for containers holding FOOD that can be readily and unmistakably recognized such as dry pasta, working containers holding FOOD or FOOD ingredients that are removed from their original packages for use in the FOOD ESTABLISHMENT, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be identified with the common name of the FOOD.
Observed a bulk food storage container held on the lower shelf of the pizza prep table to have no labeling information. - COS (Correct By: Jun 9, 2021)
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
A bag of onions were found stored on the floor of the walk-in cooler. - COS (Correct By: Jun 9, 2021)
39 C 3-305.11 (A) (B) (C): (A) Except as specified in ¶¶ (B) and (C) of this section, FOOD shall be protected from contamination by storing the FOOD: (1) In a clean, dry location; (2) Where it is not exposed to splash, dust, or other contamination; and (3) At least 15 cm (6 inches) above the floor. (B) FOOD in packages and working containers may be stored less than 15 cm (6 inches) above the floor on case lot handling EQUIPMENT as specified under § 4-204.122. (C) Pressurized BEVERAGE containers, cased FOOD in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.
a container of food product held on the storage shelf located near the pizza oven is left uncovered. - COS (Correct By: Jun 9, 2021)
41 C 3-304.14 (B)(1)(2): (B) Cloths in-use for wiping counters and other EQUIPMENT surfaces shall be: (1) Held between uses in a chemical sanitizer solution at a concentration specified under § 4-501.114; and (2) Laundered daily as specified under ¶ 4-802.11(D).
Observed wiping cloth being stored on the prep counter within the kitchen. - COS (Correct By: Jun 9, 2021)
55 C 6-501.12: (A)PHYSICAL FACILITIES shall be cleaned as often as necessary to keep them clean.(B)Except for cleaning that is necessary due to a spill or other accident, cleaning shall be done during periods when the least amount of FOOD is exposed such as after closing.
Observed the walls and floors of the kitchen area is unclean (especially under and behind kitchen equipment). Repeat
58 C Violation: certified Food protection managers have not completed allergen awareness training. Corrective Action: All employees that are certified food safety managers shall completed allergen awareness training.
 

Person In Charge

  RICK LARKINS 		 

Date:

  06/09/2021
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date:

06/10/2021

Food Establishment Inspection Report
Page 3  of ?????? 
Establishments: SAMMY'S PIZZA OF KANKAKEE Establishment #: KK175

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
HACCP Topic: PROPER COOLING PROCEDURE:(1) TIME/TEMPERTURE CONTROL FOR SAFETY FOODS (TCS) HAS AN INTERNAL TEMPERATURE OF 135F; (2) TCS FOOD IS COOLED FROM 135F TO 70F IN 2 HOURS; AND (3) THEN COOLED FROM 70F TO 40F WITHIN 4 HOURS.
 

Person In Charge

  RICK LARKINS 		 

Date:

  06/09/2021
 

Inspector

  Alan Hatia 		 

Follow-up:  Yes   No   Follow-up Date:

06/10/2021